設備罐體保溫制作封頭安裝方式罐體管道保溫工程的工藝流程及特點：1.罐體保溫工程層厚度層使用50-150mm的大型擺錘工藝巖棉、玻璃棉、硅酸鋁、復合硅酸鹽等保溫材料，特殊要求分兩層錯縫固定。外護層使用厚度為0.3-0.6mm的鍍鋅鐵皮、鋁皮、彩鋼板通過保溫的凹凸槽式壓邊機壓邊成型和防滑式滾圓機滾圓成筒進行搭接順水流方向，寬度適宜，接口平整，均勻的包裹。2.特點：具有保溫效果好、工程造價低、施工周期短、外觀美觀、防水、防火、防腐等使用年限長達30-50年的優點。主要經營：建筑、電廠、制藥 ，環保 ，石油，化工，冶金等行業．設備，管道的。鐵皮保溫、鋁皮罐體防腐保溫。鍍鋅鐵板管道保溫， PAP外護保溫。自控電伴熱帶保溫等. 主要承攬：各種設備、管道、防水、鍋爐化工、墻體保溫、水質凈化等保溫.
施工方案：1)預留300mm防火隔離帶時，可用50mm寬300mm高的瑰寶酚醛保溫板滿抹粘結砂漿粘貼在防火隔離帶處支撐其上層部分的酚醛保溫板。2)抹保溫砂漿保溫層施工至少分2-3遍，每遍所抹保溫漿料為10-20mm，施工厚度宜控制在10mm左右，注意壓實，后一遍施工厚度宜控制在10mm左右，每兩遍施工間隔應在24h以上，施工溫度偏低時，間隔時間可延長。3)保溫砂漿施工應自上而下。4)后一遍機保溫砂漿保溫 層施工時應達到灰餅沖筋厚度，并用大杠搓平，使墻面、門窗口平整度達到要求，注意保溫漿料涂抹時應壓緊壓實。5)配制好的保溫漿料應在4小時內用完，大杠刮落的保溫漿料必須在4小時內經攪拌后重新使用，嚴禁使用過時的保溫漿料。6)保溫層固化干燥后(用手按不動表面，約2-3d)，方可進行下一道工序施工，如環境溫度較低時，養護時間宜延長。適用范圍 防水巖棉板防火巖棉板巖棉制品用途廣泛，適用于建筑、石油、電力、冶金、紡織、國防、交通運輸等行業，是管道貯罐、鍋爐、煙道、熱交換器、風機、車船等工業設備隔熱、隔聲的理想材料